压缩空气工程

China wholesaler Air Dryer / Combined Air Dryer / Air Cooled Refrigerated Combined Air Dryer Compressor for Sale air compressor for car

Product Description Air Dryer / Combined air dryer / Air cooled refrigerated combined air dryer compressor for sale  Detailed Photos (1) Air-cooled combined dryer Technological Process of the Combined Low Dew Point Compressed Air Dryer   Symbol Name Symbol Name 1 Refrigerant Compressor 15 Air Pressure Gauge 2 Oil Separator 16 Heat Exchanger 3 Condenser […]

4 月 21, 2023工程与选型指南

产品描述

Air Dryer / Combined air dryer / Air cooled refrigerated combined air dryer compressor for sale
 

详细照片

(1) Air-cooled combined dryer

Technological Process of the Combined Low Dew Point Compressed Air Dryer

 

Symbol Name Symbol Name
1 Refrigerant Compressor 15 Air Pressure Gauge
2 Oil Separator 16 Heat Exchanger
3 冷凝器 17 Pressure Relief Valve
4 Dryer Filter 18,19 Check Valve
5 Sight Lens 20,21 Check Valve(Heat Type)
6 Bulge Thermal Expansion Valve 22,23,24,25 Pneumatic Valve
7 Hot Gas Bypass Valve 26,29,30,33 Diffuser
8 Vaporizer 27,31 Air Pressure Gauge
9 Humidity Sensor 28,32 Adsorption Vessel
10 Evaporator 34,35,36,37 Pilot Solenoid Valve
11 制冷剂
Low Pressure Gauge
38 Muffler
12 制冷剂
Low Pressure Gauge
39 Flow Regulating Valve(Heatless Type)
13 High and Low Pressure Controller 40 Throttling Orifice Plate(Heat Type)
14 Gas Liquid Separator 41 Electical Heater(Heat Type)
       

 General Introduction: 
Commonly, there are 2 kinds of compressed air dryer: refrigerated compressed air dryer and regeneration adsorption one. The refrigerated compressed air dryer is quite energy-saving without any air loss, While it is limited by the dew point temperature. The regeneration adsorption compressed air dryer can reach a quiet low dew point, but it has the shortcoming of big air loss and high energy consumption.
The CZPT combined low dew point compressed air dryer takes the maximum advantages of the above 2 kinds of dryers through reasonable pipeline connection and capacity matching, which ensure its economic operation and high quality of low dew point finished air.
 Operating Principle:
Firstly, the hot and wet compressed air from the compressor is heat exchange with dried cold compressed air in the heat exchanger. Then it will be cooled down to about 2ºC by evaporator. Under this pressure dew point, the majority of vapor water in the compressed air is eliminated and discharged. After these processes, the low temperature air goes into the heat exchanger to cool the high wet compressed air, at the same time, itself temperature goes up in order to prevent the condensation of dew on the surface of pipelines. Last, low moisture compressed air dryer goes into the adsorption vessel to be further dried  in order to get the good dew point.
 

(2) Water-Cooled Combined Type Air Dryer

Working condition and technical data
Maximum inlet air temperature:45ºC
Ambient temperature range:5-50ºC
Pressure range:0.6-1.0Mpa
Pressure dew point:-20ºC ~ -40ºC
Regeneration gas consumption:3-5%
Cooling mode: water cooling (industrial circulating cooling water)
Cooling water pressure range: 0.2-0.4mpa
Maximum cooling water inlet temperature: 38 ºC
Intake oil content: ≤ 0.1ppm
Power supply: 6-12nm 3 / min: AC 220 V / 50 Hz
15nm3 / min and above: AC 380V / 220V / 50Hz
Cycle: T = 40 (min)
Refrigerant: R22 (R407C / R134a optional)
Design condition: inlet temperature: 38 ºC
Ambient temperature: 38 ºC
Working pressure: 0.7MPa
Cooling water inlet temperature: 32 ºC
Pressure loss: ≤ 5% of design pressure
Note: the water-cooled equipment above 80 cubic CZPT are split bare machines. Other special requirements are welcome to customize.

Product features

  1. Low dew point:The combined low dew point dryer can reach very low pressure dew point, which can reach below – 40 ºC in general, and – 70 ºC at least according to different user requirements;
  2. Low energy consumption: the regeneration gas consumption of combined low dew point dryer is only 3% – 5%, which greatly saves the compressed air consumption;
  3. It can provide compressed air with different dew points for different air consumption points;
  4. All the operation switches and display instruments of the combined low dew point compressed air dryer are concentrated on the panel of the box plate. The refrigeration type compressed air dryer and the adsorption regeneration compressed air dryer can operate independently or simultaneously with cold and suction according to the customer’s needs;
  5. The gas-liquid separator adopts the patented three-stage separation mode: direct collision separation + low-speed centrifugal separation + stainless steel wire mesh demisting separation. 99.9% of liquid water is separated from the cooled compressed air. The second evaporation of textile moisture can ensure the low dew point quality of finished gas.
  6. High quality switching valve, stable and reliable, can ensure the integrity of the working process and prolong the working life of components.
  7. The refrigeration compressor adopts CZPT of Denmark, CZPT of ZheJiang , CZPT of Japan, CZPT of Germany, CZPT of Germany, CZPT of France and other companies of fully closed or semi closed refrigeration compressor, which has stable operation, low noise, high cop, reliable performance and long power saving life;

 

产品参数

(1) Air-Cooled Combined Type Air Dryer specification
 

模型     
  物品

空气容量
(Nm3/min)
Desiccant weight(kg) Air connector dia Refrigerant power
(HP)
空气流动
(Nm3/h)
Fan power(W) 电压
(V)
Dryer Net Weight
(千克)
Length(mm) Wideth(mm) Height(mm)
SDZF-1 1.2 25 G1″ 1/2 745 1×50 220 400 1080 850 1460
SDZF-2 2.5 40 G1″ 1/2 745 1×50 220 440 1100 900 2050
SDZF-3 3.6 60 G1″ 3/4 1330 1×100 220 460 1200 1000 1808
SDZF-4.5 5 85 G1 1/2″ 1 2670 1×135 220 660 1290 1030 2263
SDZF-6 6.8 105 G1 1/2″ 1.5 4500 1×230 220 775 1500 1105 1931
SDZF-8 8.5 150 G2″ 2 5340 2×135 220 970 1500 1240 2016
SDZF-10 10.9 185 G2″ 2.5 5340 2×135 220 1120 1500 1240 2316
SDZF-12 12.8 185 G2″ 2.5 5340 2×135 220 1120 1500 1240 2316
SDZF-15 16 310 DN65 3 7600 2×190 380/220 1700 1960 1450 2342
SDZF-20 22 395 DN65 4 7600 2×190 380/220 1800 1980 1600 2408
SDZF-25 26.8 492 DN80 5 9000 2×230 380/220 2100 2270 1700 2460
SDZF-30 32 600 DN80 6 9000 2×230 380/220 2300 2420 1780 2506
SDZF-40 43.5 725 DN100 7 12500 2×420 380/220 2700 2100 2340 2673
SDZF-50 53 855 DN100 10 13500 3×230 380/220 2900 2100 2390 2687
SDZF-60 67 1005 DN125 12 18750 3×420 380/220 3350 2250 2600 2814
SDZF-80 90 1335 DN125 13.3 25000 4×420 380/220 4200 2640 2600 2866

 

 

 

Note:Design conditions: working pressure: 7bar, inlet temperature: 38ºC, pressure dew point: -20ºC

(2) Water-Cooled Combined Type Air Dryer
 

Product specifications

模型 空气容量
(Nm3/min)
Weight of desiccant(kg) Air nozzle diameter Diameter of cooling water pipe Cooling power
(HP)
Cooling water flow
(Nm³/h)
电压
(V)
Equipment weight
(千克)
L(mm) 宽度(毫米) 唔)
SDZW-6 6.8 105 G1 1/2″ R1″ 1.5 1.2 220 760 1500 1160 1940
SDZW-8 8.5 150 G2″ R1″ 2 1.2 220 960 1500 1100 2016
SDZW-10 10.9 185 G2″ R1″ 2.5 1.6 220 1120 1500 1240 2316
SDZW-12 12.8 185 G2″ R1″ 2.5 1.8 220 1150 1500 1240 2316
SDZW-15 16 275 DN65 R1″ 3 2 380/220 1660 1960 1450 2196
SDZW-20 22 395 DN65 R1 1/2″ 4 3 380/220 1740 1970 1600 2475
SDZW-25 26.8 495 DN80 R1 1/2″ 5 3.6 380/220 2075 2030 1630 2505
SDZW-30 32 605 DN80 R1 1/2″ 6 4.6 380/220 2200 2240 1840 2519
SDZW-40 43.5 725 DN100 R1 1/2″ 7 5.6 380/220 2784 2360 1900 2637
SDZW-50 53 860 DN100 R1 1/2″ 10 7.2 380/220 3144 2400 2000 2638
SDZW-60 67 1005 DN125 R1 1/2″ 12 9.2 380/220 3361 2540 2100 2719
SDZW-80 90 1335 DN125 R1 1/2″ 13.3 10.8 380/220 4500 2640 2450 2818
SDZW-100 110 2155 DN150 R1 1/2″ 20 12.4 380/220 6550 2680 2670 2985
SDZW-120 130 2650 DN150 R2″ 25 14.6 380/220 7810 2820 2800 3041
SDZW-150 160 3205 DN200 R2″ 25 16.2 380/220 8500 3290 3130 3190
SDZW-200 210 3825 DN200 R2 1/2″ 40 18.6 380/220 9600 3350 3375 3309
SDZW-250 260 5260 DN250 R2 1/2″ 60 24.4 380/220 Detailed parameters and consultation with manufacturers
SDZW-300 315 6160 DN250 R3″ 70 30.5 380/220 Detailed parameters and consultation with manufacturers

 

Optional Accessories

  • Micro heat type
  • Dew point display
  • Dew point energy saving control
  • Special voltage
  • Environmental refrigerant
  • – 70 ºC dew point
  • Not limited to this

公司简介

 

认证

 

包装和运输

 

常问问题

 

售后服务: Ok
保修单: 1 年
Flow: Cross Flow
Material Status: Bulk
Drying Medium: 空气
Structure: All Kinds
示例:
US$ 1000/Set
1 套(最小订单)

|
索取样品

定制化:
可用的

|

空气压缩机

空气压缩机的类型

市面上有很多种空气压缩机。了解哪种最适合您的需求,以及它们之间的优劣之处。本文将详细介绍单级压缩机、无油压缩机和低噪音压缩机。我们将解释这些类型,帮助您确定所需的型号。您还可以了解单级压缩机。如果您正在寻找高质量的压缩机,本文将帮助您选择合适的机型。

空气压缩机

空气压缩机的工作原理是:通过进气阀将大气空气吸入气缸。活塞向下运动时,将大气空气吸入气缸;活塞向上运动时,将压缩空气通过排气阀排出气缸。最常见的空气压缩机类型之一是往复式压缩机。另一种压缩机类型是单级活塞式压缩机。这些类型的压缩机在一个冲程内即可完成空气压缩——相当于活塞曲轴旋转一周。
这些设备将电能或机械能转化为压缩空气。空气被压缩时,体积减小,压力增大。空气压缩机的最低压力通常为30巴。低压范围是指空气压力的范围。大多数压缩机都是独立控制的,但也可以使用网络控制器将多个压缩机连接起来。这种控制器并非适用于所有类型的压缩机。还有其他类型的空气压缩机可以相互通信。
压缩空气在各行各业都有着广泛的应用。在农业领域,它可以驱动气动物料搬运机械进行灌溉和喷洒。乳制品设备也使用压缩空气。在制药行业,压缩机还用于混合罐、包装和输送系统。便携式空气压缩机通常使用柴油作为燃料,常用于偏远的钻井现场。便携式空气压缩机在石油和天然气行业也十分常见,可用于远程控制阀门和安装反应堆反应棒。
无论您是在农业领域还是制造业中使用空气压缩机,在选择满足您需求的空气压缩机时,都需要考虑一些关键特性。一台好的压缩机应该配备安全装置。一旦达到足够的压缩量,它就会自动切断进气和排气。这些功能有助于保持空气压缩机的高效运行,并保护您的设备。安全装置是任何空气压缩机的重要特性,能够显著提高其整体效率。
叶片式空气压缩机是最常见的类型。它们通常比往复式活塞压缩机体积更小、功率更低,因此适用于功率低于100马力的应用。叶片式空气压缩机压缩比低、容量大,但通常仅限于低功率应用。叶片式压缩机运行温度较高,且压缩比通常较低。选择合适的润滑油粘度对压缩机至关重要。
空气压缩机

单阶段模型

比较单级空气压缩机时,请注意“级”这个字眼。多级压缩机采用两级结构,可以处理更大的容量和压力。第一级通过活塞和低压气缸对空气进行加压,然后将压缩空气输送到储气罐。单级压缩机通常比双级压缩机更节能。但如果您不需要高压气缸,单级空气压缩机可能是最佳选择。
虽然单级空气压缩机的功率较小,但足以驱动气动工具和其他气动设备。这些单级压缩机最适合小型家庭项目和DIY项目。对于工业用途,双级型号是最佳选择。但如果您时间紧迫,单级压缩机可能就足够了。最终,这取决于您计划如何使用空气压缩机。
单级空气压缩机只有一个气缸,每旋转一周,活塞就完成一次行程。单级压缩机通常体积更小、结构更紧凑,因此是小型工作环境的理想选择。其流量(立方英尺/分钟,cfm)是衡量其运行能力的重要指标。如果您计划使用多种气动工具,则可能需要更高流量的型号。同样,单级压缩机的功率(马力)也表明了其工作能力。1 马力每分钟可推动 550 磅/英尺的空气。
多级空气压缩机通常比单级空气压缩机更昂贵、更节能,但可以提供更高的空气流量。虽然它们结构可能更复杂,但可以降低总体运行成本。如果您计划将空气压缩机用于工业或商业用途,双级型号可能是最佳选择。但是,如果您计划将空气压缩机用于大规模生产,单级型号可能是最佳选择。
单级空气压缩机的活塞尺寸和进气口数量相同,而双级空气压缩机则具有较小的第一活塞和较长的第二活塞。两者在两个活塞之间都设有冷却管,用于在第二轮压缩前降低空气温度。单级空气压缩机通常体积小巧、便于携带,而双级空气压缩机则为固定式。这两种压缩机都有固定式和大型两种类型。

低噪声模型

尽管名为低噪音空气压缩机,但并非所有型号都一样。压缩机的噪音水平会受到多种因素的影响,包括电源和机器的距离。往复式压缩机由于运动部件较多,通常比电动压缩机噪音更大。相比之下,旋转螺杆式和涡旋式压缩机的运动部件较少,因此噪音更低。
燃气式空气压缩机的噪音可能非常大,因此不适合室内使用。为了解决这个问题,您可以选择电动型号。压缩机的噪音主要来自电机摩擦。活塞盖也是噪音的主要来源,因为活塞盖面积小的活塞会产生很大的噪音。过去,为了降低噪音,压缩机需要使用润滑油。但是,由于医疗行业对无油型号的需求,这种情况已经发生了改变。
CZPT EC28M 静音空气压缩机是另一款以静音运行为特色的机型。这款空气压缩机的噪音仅为 59 分贝,低至足以让您在它运转时进行正常的交谈。此外,这款压缩机还配备了工业级无油泵和 2.8 安培直驱式感应电机。这两项特性使其成为企业用户的理想之选。
市面上有一些适用于建筑行业的低噪音空气压缩机。然而,这些压缩机并不一定质量低劣,因此在购买前您应该考虑气动工具的噪音水平。CZPT 的专家可以根据您的具体应用和空间情况推荐合适的低噪音型号。噪音会分散在空气压缩机附近工作的人员的注意力。正因如此,许多企业现在都选择使用这类型号。
空气压缩机

无油型号

市面上有很多无油空气压缩机,但它们有什么特别之处呢?无油压缩机不含油,而是用润滑脂润滑。如果您使用的是小型压缩机,并且不想冒损坏它的风险,那么无油压缩机是一个不错的选择。但另一方面,无油压缩机会产生大量的热量,这可能会损坏压缩机。过高的压力会导致压缩机内部部件相互摩擦,甚至使其变形。
了解一些基本知识可以帮助您选择最适合您需求的无油空气压缩机。例如,压缩机的马力是衡量电机功率大小的指标。马力越大,压力(PSI)或空气流量(ACFM)就越高。您也可以使用空气流量来比较两者。涡旋式压缩机是一种现代空气压缩系统,它使用固定和移动的螺旋结构。这种结构通过将空气导向中心来减少压缩机内的空气量。
购买一台无油空气压缩机其实并不难。一位优秀的经销商可以为您推荐最适合您的无油空气压缩机类型。这样,您既可以省钱,又能安心使用。当然,要想以优惠的价格买到空气压缩机,最好的办法就是咨询一位对产品非常了解的经销商。
对于对空气污染高度敏感的企业而言,无油空气压缩机是一个绝佳的选择。例如,在制药和食品行业,即使是微量的油也可能导致产品变质,甚至损坏生产设备。由于无油空气压缩机的活动部件较少,其维护成本通常低于油浸式压缩机。因此,无油空气压缩机所需的维护较少,但可能仍需偶尔更换。
无油空气压缩机相比油润滑空气压缩机的一些优势包括噪音更低。无油空气压缩机通常噪音更小,运行更安静,但您在做决定之前仍应仔细权衡利弊。此外,在选择型号之前,还要考虑您使用空气压缩机的频率。总的来说,无油空气压缩机的优点大于缺点。最终,您会庆幸自己选择了无油空气压缩机。

China wholesaler Air Dryer / Combined Air Dryer / Air Cooled Refrigerated Combined Air Dryer Compressor for Sale   air compressor for carChina wholesaler Air Dryer / Combined Air Dryer / Air Cooled Refrigerated Combined Air Dryer Compressor for Sale   air compressor for car
editor by CX 2023-04-22